Audi A6 C5 Steering Wheel Removal

Mark the position of the steering wheel onto the spline. Worked a treat.

Audi A6 C6 S Line 2005 2011 Multi Function Steering Wheel With Spiral Sensor Use Ebay

Remove the wiring harness connectors from the airbag.

Audi a6 c5 steering wheel removal. There is one more black harness remove the small terminal at the bottom of the wheel. Remove the drivers side knee panel and set it out of the way. I have a quick fix.

If you have a bit of a thumb nail you can pop off the covers for the screws or get a small screw driver and work them off. Remove the two Phillips screws holding the bottom of the instrument cluster. I used a yellow paint marker.

Audi A6 S6 C6-4F 2006 Steering wheel 4F0419091BT LGV11126. WD40 dont last that long. Youll need to get a 12mm XZN driver commonly known as a triple square to loosen and remove the nut.

Audi A1 A3 A4 A5 A6 A7 Q3 Q5 S-Line steering wheel badge sticker logo s line RS. How to Remove Lower Steering Wheel Cowl - Audi A6 S6 RS6 - C5 - 1997 - 2005. This video will show you how to remove your Lower Steering Wheel Cowl Shroud from your Audi A6 S6 or RS6 C5 1997-2005.

See the picture below. You need a 12mm triple square driver to remove it but it comes out easy. I have looked.

Is it difficult to adjust the pre-load on the steering rack gear for a 2004 Audi A6 27T. Remove that and the wheel will be loose and you can adjust it as it has really fine splines. Hey there fellow AZs I just picked up a 04 A6 27t and am going to do a full interior swap.

This video will show you how to remove the Steering Wheel from your Audi A6 S6 or RS6 C5 1997-2005Looking for tools. This video will show you how to remove your Upper Steering Wheel Cowl Shroud from your Audi A6 S6. Pull the locking tabs back and pull the yellow electrical connector off.

Remove the bolt holding the steering wheel in place using the M12 tool. Remove the steering wheel bolt. 6 Nm 53 in lb Remove airbag -3- and disconnect connector.

It is not necessary to remove the steering wheel for any part of this installation. Drivers door closed and wont open from inside or outside. In the center of the steering wheel is a bolt.

Large Image Extra-Large Image. Theres a torx bolt at about 4 o clock and 8 o clock behind the steering wheel remove these and the airbag will come off and just remove the plug that connects the electrics then its just a case of removing the horn spade connectors and the big torx nut will be facing you. Does any one know how to remove the steering wheel airbag cover on an a6 C5 I know about disconnect battery but dont know how to release the airbag cover in the centre of the steering wheel i suspect it is some thing to do with the two holes in the rear of the steering wheel.

It is important that you read the instructions carefully as there is a risk of triggering the airbag accidentally. Turn the steering wheel so that the screws on the rear of the steering wheel are at the top and bottom of the steering wheel this will make access easier. The steering wheel is held to the steering shaft by a large bolt green arrow.

This way you can spay lube behind the steering wheel without removal. Note one of the two locking tabs blue arrow for the underside of the clockspring as referenced in Picture 1. You can reach them from the wheel well Remove the wheel on the DS.

These are likely to be extremely tight. Airbag sport steering wheel aftermarket installation 1995 series production vehicles can be converted to the airbag sport steering wheel. Youll need to remove the airbag to access the retaining bolt for the steering wheel.

PastAudi A6 19TDI 2000. Press the tab purple arrow on the electrical connector and pull it off the clockspring. Ive also heard of people using a T55 Torx driver to do this but you risk stripping out the inside of the nut.

When installing the airbag unit in the steering wheel tighten the right Torx bolt firstOnly then tighten the left Torx bolt 6 Nm 53 in lb. Remove the Torx screws from the back of the steering wheel. How to Remove Lower Dash Panel Under Steering Wheel - Audi A6 S6 RS6 - C5 - 1997-2005 Step 3.

Loosen bolts -6- from back side. The steering has some play in it more than I think it should. I tried searching without much luck.

2002 Audi A6 C5 27T. Tuning S-LINE Flattened Leather Steering Multifunction Black Audi A4 8E 8K A6 A5. If theres one that I missed please forgive me and post it here so I can get to work.

Get some WD40 with the straw Heat the very end of the straw and put a slight curve on it. Begin by reading through our article on Airbag Removal. So now im adapting the straw to work with silicone spray.

Remove the wiring connector from the steering wheel and pull the wheel off. I know how to take everything but the center console and dash out. The picture shows the steering wheel removed.

Step one after the battery is to remove the steering wheel. Once you have the bolt removed. Audi A6 Sedan 1998-2004 Audi A6 Avant 1999-2004 Audi allroad quattro 2001-2004 Audi S6 Avant 2002-2004 Audi RS6 2003-2004 - Suspension Wheels Steering 40-16 Removing Pressing-out tool VAS 6085 components 1 - Body 2 - Adapter 3 - Thrust bolt M10 x 125 x 95 4 - Threaded sleeve 5 - Press tool length 78 mm 6 - Press tool length 98 mm.

How To Remove Lower Steering Wheel Cowl Audi A6 S6 Rs6 C5 1997 2005 Total Technik Youtube